SUPPLY & INSTALLATION OF HV SYSTEM

PROJECT BRIEF
This Project is aimed at designing, supplying and Installing High Voltage Power Connection for the entire Plant. It includes the supply and Installation of 4 Set Ring Main Unit (HV Switchgear) complete with a Landis Relay, installation and commissioning of a 2MVA Transformer as well as the supply and Installation of the main HV Cable from the HV Switchgear to the Transformer. Entire system is tested, commissioned and handed over to client after Installations.

SCOPE OF WORK
The scope of work included the Design, Supply and Installation of Ring main unit, Metering Panel, HV Cable and HV termination accessories. Factory Acceptance Test and Site Acceptance Test was conducted with the client before commencement of work.  Prior to project closure, commissioning works and Training was conducted and handed over project to client.

ELECTRICAL & MECHANICAL WORKS FOR ETIX DATA CENTRE

PROJECT BRIEF
The data centre is a multi-tenant (carrier and vendor neutral) Tier IV data centre in Accra, Ghana.

SCOPE OF WORK

Mechanical, Electrical & Plumbing works :

  1. Underground conduit work
  2. Above ground conduit work
  3. Cable tray work
  4. LV and network cabling and termination
  5. Lighting works for DC, perimeter and office building
  6. Above ground earthing works (cable tray earthing)
  7. Lighting
  8. CCTV
  9. Access control and Intrusion for office and DC
  10. Water Leak Detection for the DC
  11. BMS cabling and termination
  12. Air conditioning in office building
  13. Air handline Unit duct work
  14. Drainage and plumbing (sanitary fittings)
  15. Raised floor
  16. Elevator

PUMA ENERGY - 110 MW THERMAL POWER PLANT

PROJECT BRIEF
On May 24, 2018 the electrical installation and commissioning of the 107 Megawatts combined power cycle plant for Ghana Power Generation Company Limited began. The Plant consisted of 2 gas generators with the excess heat fuelling a boiler for steam production. steam produced is supplied to 2 steam generators for additional power generation. Process and plant automation limited did the plant electrical installation as well as the commissioning.

SCOPE OF WORK

  1. Testing of Electrical panels
  2. Laying of Cable trays
  3. Routing of Cables
  4. Engineering (Cable Callout, Cable Block Diagram)
  5. Instrumentation
  6. Cable Terminations (Low Voltage Cables and Medium Voltage Cables)
  7. Testing and Commissioning

ELECTRICAL INSTALLATION WORKS FOR PREMIUM FOODS

PROJECT BRIEF
The factory is located at Kwaso in the Ashanti region of Ghana. It is a grain storage and processing facility that is capable of storing 16800 tons of grain including rice, maize, wheat and soyabeans. The facility has four (4) 8000 cubic meter silos for storing grains. It has five(5) 50 cubic meter buffer silos for storing 500 tons of ready to use grains. There are conveyors, elevators, grain cleaners, motorized gate values and a system of sensors and actuators for process control.
The project deliverables include the following:

  1. Providing a temporal substation (for powering the silo facility).these includes running and termination of cables and commissioning.
  2. Cable running and termination for motors, sensors and actuators.
  3. Lighting wiring and installation for the silo facility.
  4. Cabling and termination in motor control centre (MCC) panel.
  5. Testing of MCC panel including starters and local controls6. general commissioning and fine tuning of conveyors, elevators, sensors and actuators.

SCOPE OF WORK

  1. Design and approval of electrical works for silo facility.
  2. Cable ladder works.
  3. Armoured cable running and termination for power to the silo facility.
  4. Cable running and termination for motors.
  5. Control cable running and termination for sensors and actuators.
  6. Installation of sensors and actuators.
  7. Installation and termination in MCC panel.
  8. Cabling and installation of lighting for the silo area and tunnels.
  9. Installation of temporal power for the silo facility.
  10. Testing and commissioning of the silo facility